Product ID:KUT ZIT
MSDS Date:09/01/1986
FSC:7930
NIIN:00N078846
MSDS Number: CGYPG

SAVOGRAN

NORWOOD, MA 02062
US

Emergency Phone: 617-762-5400

Info Phone: 617-762-5400

Preparer: JOHN L GALE

Cage: 86885

SAVOGRAN

130 NORWOOD, MA 02062 US

Telephone: 617-762-5400

Cage: 86885

METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: <30%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM, A2

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ALCOHOL (METHANOL) (SARA 313) (CERCLA)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <30%

OSHA PEL 200 PPM, S

ACGIH TLV: 200PPM/250 STEL, S

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <30%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETONE (SARA 313) (CERCLA)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: <30%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM/1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PARAFFIN WAX

CAS: 8002-74-2

RTECS: RV0350000

Fraction By Weight: <2%

OSHA PEL 2 MG/M3 (FUME)

ACGIH TLV: 2 MG/M3 (FUME)

OTHER FLAMES. VAPS CONT FLAME, SPKS/HOT SURF MAY

RTECS: 9999999ZZ

METALS. CUTTING TORCHES ON/NEAR CONTRS (EMPTY/FULL)

RTECS: 9999999ZZ

THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND

RTECS: 9999999ZZ

LIVER & KIDNEY DMG. EXCESS EXPOS MAY CAUSE

RTECS: 9999999ZZ

DRINKING ALCOHOL SHORTLY

RTECS: 9999999ZZ

UNDESIRABLE EFTS. CHLOROCARBON MATLS HAVE PRDCED

RTECS: 9999999ZZ

COULD HAVE SIMILAR EFTS IN HUMANS. ADRENOMIMETICS

RTECS: 9999999ZZ

LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY

RTECS: 9999999ZZ

THE NAVY OCCUP CHEM REPRO HAZ LIST. SEEK CONSULT

RTECS: 9999999ZZ

LIST INFORMATION AND SAFE HANDLING AND EXPOSURE

RTECS: 9999999ZZ

GET MEDICAL ATTENTION IMMEDIATELY. NEVER

RTECS: 9999999ZZ

DO NOT USE CUTTING/WELDING TORCHES NEAR

RTECS: 9999999ZZ

TANKS/OTHER CONTRS UNLESS SUITABLE NIOSH APPRVD POS

RTECS: 9999999ZZ

USED & OBSERVER IS PRESENT TO RENDER ASSIST. NOTE

RTECS: 9999999ZZ

CONTRS MAY EXPLODE IF EXPOSED TO EXTREME HEAT.

RTECS: 9999999ZZ

CONTR. EMPTIED CONTRS MAY RETAIN PROD RESIDUES (VAP

RTECS: 9999999ZZ

MUST BE OBSERVED UNTIL CONTR IS THORO

RTECS: 9999999ZZ

OF MATL IN BOTTOM OF 55 GAL CONTR) BEFORE DISP. IF

RTECS: 9999999ZZ

RECONDITIONER FOR CLEANING. NO SMKNG IN AREA OF

RTECS: 9999999ZZ

OR HOT SURFACES. HEAT AND/OR UV RADIATION MAY CAUSE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAN CAUSE SEV IRRIT,
REDNESS, TEARING, BLURRED VISION. MAY CAUSE TRANSIENT INJURY TO
CORNEA. SKIN: SHORT CONT: NO IRRIT. PRLNG/FREQUENTLY RPTD CONT CAN
CAUSE IRRIT, DEFAT, DERM. INHAL: EX CESS INHAL OF VAPS CAN CAUSE
NASAL & RESP IRRIT, DIZZ, WEAK, FATG, HDCH, NAUS, UNCON &
ASPHYXIATION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONO, SUPP, VOL
7, PG 194, 1987: GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:
(SUP DAT)
Effects of Overexposure:HLTH HAZ: INGEST: ASPIR OF MATL INTO LUNGS CAN
CAUSE CHEM PNEUMIT WHICH CAN BE FATAL. INGEST CAN CAUSE BLINDNESS,
NAUS, VOMIT, DIARR, GI IRRIT & DEATH. CHRONIC: INTENTIONAL MISUSE
BY DELIBERATELY CONC & INHALING PROD MAY BE HARMFUL/FATAL. RPTS
HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN, NERV SYS,
(ING 9)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN: WASH THORO W/SOAP & WATER. THORO LAUNDER CONTAM CLTHG
BEFORE REUSE. EYE: FLOOD W/PLENTY OF WATER W/EYELIDS HELD OPEN FOR
AT LEAST 15 MIN & GET MED ATTN IMMED. INHAL: REMOVE TO FRESH AIR.
IF BRTH G IS DFCLT GIVE OXYGEN. IF BRTHG HAS STOPPED START ARTF
RESP. CALL MD IMMED. INGEST: IMMED GIVE 1-2 GLASSES OF WATER & CALL
MD, HOSPITAL EMER ROOM/POIS CTL CTR FOR WAY TO INDUCE VOMIT. (ING
16)

Flash Point Method:TOC
Flash Point:>80F,>27C
Extinguishing Media:WATER FOG, REGULAR FOAM, CARBON DIOXIDE OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT . STRAIGHT WATER STREAM WILL SPREAD FIRE.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG SURF,
COLLECT IN LOW AREAS & MAY BE MOVED BY VENT & MAY IGNITE EXPLO AT
LOCATIONS FAR REMOVED FROM HNDLG LOCATION. (SUP DAT)

Spill Release Procedures:SML SPILL: WIPE/SCRAPE UP ANY MATL. WASH AREA
THORO W/DETERGENT & WATER; VENT ADEQ W/GOOD FRESH AIR MOVEMENT AT
FLOOR LEVEL. LGE SPILL: WEAR PROPER PROT EQUIP. FOR MORE SPECIFIC
INFO CONT NEHC .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL PLACE, OUT OF HOT SUN &
< 90F. ALL CONTRS ARE SUBJECT TO DMG IN STOR & TRANSIT. DAMAGED
CONTRS MAY START LEAKING IMMED/AT LATER TIME.
Other Precautions:DO NOT STORE FLAM MATLS IN AREAS W/WIDELY FLUCTUATING
TEMPS & DO NOT STORE WHERE VAPS MAY COME IN CONT W/FLAMES,
SPKS/HEAT. FLAM MATLS SHOULD NOT BE STORED IN BELOW GROUND AREAS
THAT CANNOT BE ADEQ VE NTILATED AT FLOOR LEVEL. (ING 17)

Respiratory Protection:FOR LEVELS <2% FOR 1/2 HR/LESS, USE NIOSH APPRVD
FULL-FACE MASK W/CANISTER FOR ORG VAPS & METHANOL. ABOVE 2% & EMER,
USE NIOSH APPRVD SCBA W/FULL FACE PIECE OPERATED IN PRESS
DEMAND/OTHER POS PRESS MO DE (SEE YOUR SFTY EQUIP SUPPLIER).
Ventilation:ADEQ VENT MUST BE PROVIDED W/GOOD FRESH AIR MOVEMENT AT
FLOOR LEVEL BY NORM CROSS VENT/PREF EXPLO-PROOF EXHST FANS.
Protective Gloves:COTTON LINED NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
LONG SLEEVED SHIRTS & LONG PANTS TO PROT SKIN AGAINST
SPLASHES/SPILLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANTIC TO BE CARCIN. ANIMAL: LIVER. EXPLO HAZ: KEEP
AWAY FROM SPKS & OTHER FLAMES. USE ONLY IN EXPLO-PROOF AREAS/TURN
OFF ELEC. NO SMKNG. DO NOT OPERATE ELEC SWITCHES/MOTORS. PVNT MET
AL OBJECTS FROM STRIKING OTHER METAL OBJECTS WHICH MAY CAUSE SPKS.
TURN OFF PILOT LIGHTS, ELEC IGNITERS & ALL (ING 6)

Boiling Pt:B.P. Text:>104F,>40C
Vapor Pres:RETARDED
Vapor Density:HVR/AIR
Spec Gravity:0.90
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:BLUE LIQUID WITH WHITE SOLIDS, AROMATIC ODOR
Percent Volatiles by Volume:>90

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIES, AND STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS, HYDROGEN CHLORIDE, SMALL AMOUNTS OF PHOSGENE
& CHLORINE.

Waste Disposal Methods:REMOVER CANNOT BE NEUT FOR DISP INTO SEWER.
SOLVS MUST NOT BE DUMPED ON GROUND/BE ALLOWED TO CONTAM GROUND
WATER, STREAMS, DRINKING WATER SOURCES/OTHER BODIES OF WATER.
COMPLY W/ALL LOC, STATE & FED R EGS. CONT NEHC FOR MORE SPECIFIC
INFO .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.